Press Information

MHI's Turboden to Provide Sustainable Power to Indigenous First Nations in Saskatchewan, Canada

Print

・ 8,000 kW Project enhances environmental and economic sustainability of community thanks to carbon-neutral heat and power generation with woody biomass fuel

・ System to power 5,000 homes and significantly improve air quality

Tokyo, February 10, 2020 - Turboden S.p.A, a group company of Mitsubishi Heavy Industries, Ltd. (MHI) based in Brescia, Italy, has concluded a contract to provide the Meadow Lake Tribal Council (MLTC), representing nine Indigenous First Nations in Saskatchewan, Canada, with a 8,000 kW Organic Rankine Cycle (ORC) power generation system that uses sawmill residual woody biomass as fuel.

The carbon-neutral power project, operating under the name of the MLTC Bioenergy Centre, will be located near Meadow Lake, Saskatchewan within the traditional territory of the nine First Nations of the Meadow Lake Tribal Council (MLTC). The green power generation facility, with major equipment supplied by Turboden, is a project of the Meadow Lake Tribal Council, supported with funding from the Government of Canada. The facility will produce electricity from an ORC system(Note) utilizing Turboden's technology, with biomass fuel derived from residual wood waste from the adjacent, MLTC-owned NorSask Forest Products LP (NorSask) sawmill as heating fuel. The system is expected to produce 6,600kW (net) of carbon neutral baseload electricity to power approximately 5,000 homes. The project is expected to decrease greenhouse gas emissions by more than one million tonnes over 25 years (equivalent to CO2 emission of more than 50,000 vehicles per year), as well as significantly reduce smoke and other harmful particulate matter, improving the local air quality conditions. In addition to the generated electricity, the cogeneration system design provides process heat to the NorSask sawmill buildings as well as new high efficiency lumber dry kiln, which will reduce natural gas consumption and also improve the economics of Canada's largest 100% Indigenous-owned sawmill facility.

Turboden was founded in 1980 by professors from Polytechnic University of Milan, and has been focused on the use of ORC power generation systems. The company became part of MHI Group in 2013. In 2016, Turboden signed a contract with general machinery trading company Daiichi Jitugyo making the firm its sales distributor in Japan.

In October 2019, Turboden's 995 kW ORC cycle power generation system was adopted for a project in Nankan-machi (Kumamoto Prefecture) using bamboo biomass, as the primary fuel, which had been considered difficult to process in Japan. As the first such initiative in Japan, the project is supported by Japan's national research and development agency, the New Energy and Industrial Technology Development Organization (NEDO), which is seeking to promote the introduction of biomass energy.

MHI Group will exhibit at the "The 10th International Smart Grid Expo" to be held at Tokyo Big Sight from February 26, 2020. MHI Group's "NEXT ENERGY" booth will also include an introduction to Turboden's ORC power generation system.

MHI, as a global corporation that provides wide-ranging and highly efficient power generation and energy systems, will work closely with Turboden to continue the successful adoption of binary cycle power generation systems globally, contributing to a more sustainable energy mix.

  • Turboden's binary cycle power generation system has as its core component an Organic Rankine Cycle (ORC) turbine, which uses as the boiling medium organic material with a low boiling point, such as a fluorocarbon or hydrocarbon-based material. This permits the use of relatively low-temperature heat sources such as biomass, factory waste heat, and geothermal energy. The system can generate up to 40,000kW of electricity, and can be easily installed in non-fuel producing regions or areas lacking water resources, such as inland areas, deserts, and islands. It is also able to provide stable power generation without being subject to the weather or other factors.
Biomass Incinerators
Biomass Incinerators
ORC cycle power generation system (Combined Heat and Power system)
ORC cycle power generation system (Combined Heat and Power system)